Several chromosomally expressed AceE variants were constructed in
- Award ID(s):
- 1802533
- NSF-PAR ID:
- 10282570
- Editor(s):
- Atomi, Haruyuki
- Date Published:
- Journal Name:
- Applied and Environmental Microbiology
- Volume:
- 87
- Issue:
- 13
- ISSN:
- 0099-2240
- Format(s):
- Medium: X
- Sponsoring Org:
- National Science Foundation
More Like this
-
Abstract Escherichia coli ΔldhA ΔpoxB ΔppsA and compared using glucose as the sole carbon source. These variants were examined in shake flask cultures for growth rate, pyruvate accumulation, and acetoin production via heterologous expression of thebudA andbudB genes fromEnterobacter cloacae ssp. dissolvens . The best acetoin‐producing strains were subsequently studied in controlled batch culture at the one‐liter scale. PDH variant strains attained up to four‐fold greater acetoin than the strain expressing the wild‐type PDH. In a repeated batch process, the H106V PDH variant strain attained over 43 g/L of pyruvate‐derived products, acetoin (38.5 g/L) and 2R,3R‐butanediol (5.0 g/L), corresponding to an effective concentration of 59 g/L considering the dilution. The acetoin yield from glucose was 0.29 g/g with a volumetric productivity of 0.9 g/L·h (0.34 g/g and 1.0 g/L·h total products). The results demonstrate a new tool in pathway engineering, the modification of a key metabolic enzyme to improve the formation of a product via a kinetically slow, introduced pathway. Direct modification of the pathway enzyme offers an alternative to promoter engineering in cases where the promoter is involved in a complex regulatory network. -
Abstract The microbial product citramalic acid (citramalate) serves as a five‐carbon precursor for the chemical synthesis of methacrylic acid. This biochemical is synthesized in
Escherichia coli directly by the condensation of pyruvate and acetyl‐CoA via the enzyme citramalate synthase. The principal competing enzyme with citramalate synthase is citrate synthase, which mediates the condensation reaction of oxaloacetate and acetyl‐CoA to form citrate and begin the tricarboxylic acid cycle. A deletion in thegltA gene coding citrate synthase prevents acetyl‐CoA flux into the tricarboxylic acid cycle, and thus necessitates the addition of glutamate. In this study theE. coli citrate synthase was engineered to contain point mutations intended to reduce the enzyme's affinity for acetyl‐CoA, but not eliminate its activity. Cell growth, enzyme activity and citramalate production were compared in several variants in shake flasks and controlled fermenters. Citrate synthase GltA[F383M] not only facilitated cell growth without the presence of glutamate, but also improved the citramalate production by 125% compared with the control strain containing the native citrate synthase in batch fermentation. An exponential feeding strategy was employed in a fed‐batch process using MEC626/pZE12‐cimA harboring the GltA[F383M] variant, which generated over 60 g/L citramalate with a yield of 0.53 g citramalate/g glucose in 132 hr. These results demonstrate protein engineering can be used as an effective tool to redirect carbon flux by reducing enzyme activity and improve the microbial production of traditional commodity chemicals. -
ABSTRACT Fermentation-based chemical production strategies provide a feasible route for the rapid, safe, and sustainable production of a wide variety of important chemical products, ranging from fuels to pharmaceuticals. These strategies have yet to find wide industrial utilization due to their inability to economically compete with traditional extraction and chemical production methods. Here, we engineer for the first time the complex microbial biosynthesis of an anthocyanin plant natural product, starting from sugar. This was accomplished through the development of a synthetic, 4-strain Escherichia coli polyculture collectively expressing 15 exogenous or modified pathway enzymes from diverse plants and other microbes. This synthetic consortium-based approach enables the functional expression and connection of lengthy pathways while effectively managing the accompanying metabolic burden. The de novo production of specific anthocyanin molecules, such as calistephin, has been an elusive metabolic engineering target for over a decade. The utilization of our polyculture strategy affords milligram-per-liter production titers. This study also lays the groundwork for significant advances in strain and process design toward the development of cost-competitive biochemical production hosts through nontraditional methodologies. IMPORTANCE To efficiently express active extensive recombinant pathways with high flux in microbial hosts requires careful balance and allocation of metabolic resources such as ATP, reducing equivalents, and malonyl coenzyme A (malonyl-CoA), as well as various other pathway-dependent cofactors and precursors. To address this issue, we report the design, characterization, and implementation of the first synthetic 4-strain polyculture. Division of the overexpression of 15 enzymes and transcription factors over 4 independent strain modules allowed for the division of metabolic burden and for independent strain optimization for module-specific metabolite needs. This study represents the most complex synthetic consortia constructed to date for metabolic engineering applications and provides a new paradigm in metabolic engineering for the reconstitution of extensive metabolic pathways in nonnative hosts.more » « less
-
Formaldehyde is a prevalent environmental toxin and a key intermediate in single carbon metabolism. The ability to monitor formaldehyde concentration is, therefore, of interest for both environmental monitoring and for metabolic engineering of native and synthetic methylotrophs, but current methods suffer from low sensitivity, complex workflows, or require expensive analytical equipment. Here we develop a formaldehyde biosensor based on the FrmR repressor protein and cognate promoter of
Escherichia coli . Optimization of the native repressor binding site and regulatory architecture enabled detection at levels as low as 1 µM. We then used the sensor to benchmark the in vivo activity of several NAD‐dependent methanol dehydrogenase (Mdh) variants, the rate‐limiting enzyme that catalyzes the first step of methanol assimilation. In order to use this biosensor to distinguish individuals in a mixed population of Mdh variants, we developed a strategy to prevent cross‐talk by using glutathione as a formaldehyde sink to minimize intercellular formaldehyde diffusion. Finally, we applied this biosensor to balance expression ofmdh and the formaldehyde assimilation enzymeshps andphi in an engineeredE. coli strain to minimize formaldehyde build‐up while also reducing the burden of heterologous expression. This biosensor offers a quick and simple method for sensitively detecting formaldehyde, and has the potential to be used as the basis for directed evolution of Mdh and dynamic formaldehyde control strategies for establishing synthetic methylotrophy. -
Abstract Chinese hamster ovary (CHO) cells, predominant hosts for recombinant biotherapeutics production, generate lactate as a major glycolysis by‐product. High lactate levels adversely impact cell growth and productivity. The goal of this study was to reduce lactate in CHO cell cultures by adding chemical inhibitors to hexokinase‐2 (HK2), the enzyme catalyzing the conversion of glucose to glucose 6‐phosphate, and examine their impact on lactate accumulation, cell growth, protein titers, and
N ‐glycosylation. Five inhibitors of HK2 enzyme at different concentrations were evaluated, of which 2‐deoxy‐d ‐glucose (2DG) and 5‐thio‐d ‐glucose (5TG) successfully reduced lactate accumulation with only limited impacts on CHO cell growth. Individual 2DG and 5TG supplementation led to a 35%–45% decrease in peak lactate, while their combined supplementation resulted in a 60% decrease in peak lactate. Inhibitor supplementation led to at least 50% decrease in moles of lactate produced per mol of glucose consumed. Recombinant EPO‐Fc titers peaked earlier relative to the end of culture duration in supplemented cultures leading to at least 11% and as high as 32% increase in final EPO‐Fc titers. Asparagine, pyruvate, and serine consumption rates also increased in the exponential growth phase in 2DG and 5TG treated cultures, thus, rewiring central carbon metabolism due to low glycolytic fluxes.N ‐glycan analysis of EPO‐Fc revealed an increase in high mannose glycans from 5% in control cultures to 25% and 37% in 2DG and 5TG‐supplemented cultures, respectively. Inhibitor supplementation also led to a decrease in bi‐, tri‐, and tetra‐antennary structures and up to 50% lower EPO‐Fc sialylation. Interestingly, addition of 2DG led to the incorporation of 2‐deoxy‐hexose (2DH) on EPO‐FcN ‐glycans and addition of 5TG resulted in the first‐ever observedN ‐glycan incorporation of 5‐thio‐hexose (5TH). Six percent to 23% ofN ‐glycans included 5TH moieties, most likely 5‐thio‐mannose and/or 5‐thio‐galactose and/or possibly 5‐thio‐N ‐acetylglucosamine, and 14%–33% ofN ‐glycans included 2DH moieties, most likely 2‐deoxy‐mannose and/or 2‐deoxy‐galactose, for cultures treated with different concentrations of 5TG and 2DG, respectively. Our study is the first to evaluate the impact of these glucose analogs on CHO cell growth, protein production, cell metabolism,N ‐glycosylation processing, and formation of alternative glycoforms.