An official website of the United States government
The ability of a natural ice-binding protein from Shewanella frigidimarina (SfIBP) to inhibit ice crystal growth in highly alkaline solutions with increasing pH and ionic strength was investigated in this work. The purity of isolated SfIBP was first confirmed via sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE) and size-exclusion chromatography with an ultraviolet detector (SEC-UV). Protein stability was evaluated in the alkaline solutions using circular dichroism spectroscopy, SEC-UV, and SDS-PAGE. SfIBP ice recrystallization inhibition (IRI) activity, a measure of ice crystal growth inhibition, was assessed using a modified splat assay. Statistical analysis of results substantiated that, despite partial denaturation and misfolding, SfIBP limited ice crystal growth in alkaline solutions (pH ≤ 12.7) with ionic strength I ≤ 0.05 mol/L, but did not exhibit IRI activity in alkaline solutions where pH ≥ 13.2 and I ≥ 0.16 mol/L. IRI activity of SfIBP in solutions with pH ≤ 12.7 and I ≤ 0.05 mol/L demonstrated up to ≈ 66% reduction in ice crystal size compared to neat solutions.
more »
« less
Soy protein processing impacts the ice recrystallization inhibition activity of protein hydrolysates
Abstract Soy protein hydrolysates have demonstrated moderate ice recrystallization inhibition (IRI) activity, but the properties of the unhydrolyzed protein contributing to this activity are not well known. The objective of this research was to identify the main protein processing factors important to the varying IRI activities observed. Three possible modification reactions were applied to soy protein isolate (SPI): the Maillard reaction that can occur in soy flour before protein isolation, heat denaturation of the fully defatted protein, and heat denaturation of the protein with the presence of residual lipid, mainly polar phospholipids. These modified proteins were hydrolyzed by Alcalase protease (for 2 min) to produce hydrolysates, which were characterized by HPLC and FTIR to investigate how molecular weight (MW) and changes in secondary structure relate to IRI activity. A multilinear regression with the parameters of modification type, surface hydrophobicity, secondary structure profile, and average MW of the hydrolysates was used to investigate their roles in reducing ice crystal size. It was discovered that polar lipids present in the soy hydrolysate samples and MW were the only significant factors (p < 0.05) for IRI activity of SPI hydrolysates which had an ice crystal size reduction from 22.0% to 36.7%. This study demonstrates for the first time a protein hydrolysate‐phospholipid interaction can produce IRI active molecules.
more »
« less
- Award ID(s):
- 2103558
- PAR ID:
- 10543143
- Publisher / Repository:
- Wiley Blackwell (John Wiley & Sons)
- Date Published:
- Journal Name:
- Sustainable Food Proteins
- Volume:
- 2
- Issue:
- 4
- ISSN:
- 2771-9693
- Format(s):
- Medium: X Size: p. 223-235
- Size(s):
- p. 223-235
- Sponsoring Org:
- National Science Foundation
More Like this
-
-
Abstract Black soldier fly larvae (BSFL) have demonstrated cold tolerance that suggests the presence of cryoprotective molecules. The objective of this research was to investigate if the proteins present in the BSFL have ice recrystallization inhibition (IRI) activity and how different environmental factors affect the activity. Osborne fractionation of the defatted BSFL was performed to separate the proteins based on solubility, then preparative size exclusion chromatography was used to fractionate the albumin fraction by molecular size to isolate IRI or ice binding proteins. The major proteins in the active fractions were identified by mass spectrometry, and molecular dynamic simulations were performed with two proteins identified to investigate their behaviors in an ice-water system. The main finding is the strong IRI activity of the water-soluble BSFL albumin fraction and the column fractionated fraction 1. This fraction had a 40.4-79.9% reduction in ice crystal size at 1% concentration and under a wide pH (3-9) and salt (10-200 mM NaCl) concentration. Pure proteins recovered were sequenced and identified as cuticle proteins by mass spectrometry. One cuticle protein demonstrated strong H-bonding and structural flexibility by molecular dynamic simulations, explaining the IRI and ice binding activity. This is the first time BSFL protein is reported to possess IRI activity, and such protein extract can be feasibly obtained compared to other naturally occurring antifreezing proteins.more » « less
-
Abstract Implications of excess phosphorus (P) in waste streams obtained from soy‐based protein preparation processes on the environment and their potential utilization as P‐source are two significant understudied areas. Soybean‐based protein ingredients for food products retain comparatively enhanced functional properties and are cheaper than other plant‐based proteins. Soybean protein can be extracted and utilized as a food ingredient primarily by preparing soy protein concentrates (SPC) and soy protein isolates (SPI) from soybean meal/defatted soy flour (DSF). In a typical soybean processing facility, along with the soy products and soy‐protein preparations, the recovery of phosphorus as a coproduct will enhance the economic feasibility of the overall process as the recovered P can be used as fertilizer. In this study, the SPC and SPI were prepared from the DSF following widely used conventional protocols and P flow in these processes was tracked. In SPC production, ~59% of the total P was retained with SPC and ~34% was in the aqueous waste streams. For SPI process ~24% of total P was retained with SPI and ~59% went in the waste solid residue (~40%) and aqueous streams (~19%). About 80%–89% P removal from the waste aqueous streams was achieved by Ca‐phytate precipitation. This work demonstrated that in the process of SPC and SPI preparation the phosphorus from the waste aqueous streams can be precipitated out to avoid subsequent eutrophication and the waste solid residue with ~40% P can be reused as a P‐fertilizer as other applications of this residue are unspecified.more » « less
-
Pulse proteins, such as pea and chickpea proteins, have inferior functionality, specifically gelation, compared to soy protein, hindering their applications in different food products, such as meat analogs. To close the functionality gap, protein polymerization via targeted modification can be pursued. Accordingly, transglutaminase-induced polymerization was evaluated in pea protein isolate (PPI) and chickpea protein isolate (ChPI) to improve their functionality. The PPI and ChPI were produced following a scaled-up salt extraction coupled with ultrafiltration (SE-UF) process. Transglutaminase (TGase)-modified PPI and ChPI were evaluated in comparison to unmodified counterparts and to commercial protein ingredients. Protein denaturation and polymerization were observed in the TG PPI and TG ChPI. In addition, the TGase modification led to the formation of intermolecular β-sheet and β-turn structures that contributed to an increase in high-molecular-weight polymers, which, in turn, significantly improved the gel strength. The TG ChPI had a significantly higher gel strength but a lower emulsification capacity than the TG PPI. These results demonstrated the impact of the inherent differences in the protein fractions on the functional behavior among species. For the first time, the functional behavior of the PPI and ChPI, produced on a pilot scale under mild processing conditions, was comprehensively evaluated as impacted by the TGase-induced structural changes.more » « less
-
Abstract Self‐healing green thermoset soy protein isolate (SPI) based resins, crosslinked with cinnamaldehyde (CA), were developed. Self‐healing was achieved using elongated microcapsules (MCs) as against spherical MCs that have been used in most earlier studies. MCs containing SPI solution as healant within poly(d,l‐lactide‐co‐glycolide) shells were prepared using Water‐in‐oil‐in‐water (w/o/w) emulsion solvent evaporation (ESE) technique. Process parameters such as sodium tripolyphosphate (STP) and poly(vinyl alcohol) (PVA) concentrations and stirring speed were optimized to obtain elongated MCs. The average aspect ratio of MCs was over four. SPI resins crosslinked with 10% CA (10%CA‐SPI) increased Young's modulus and fracture stress by 54% and 87%, respectively, compared with their noncrosslinked counterpart. The resins containing 15% elongated MCs (15%MC‐10%CA‐SPI) showed self‐healing efficiencies of over 42% in fracture stress and about 35% in toughness recovery, after 24 h of healing. Improvement in self‐healing can be attributed to the high aspect ratio of the MCs that increases the probability of MCs being in the path of the microcracks and releasing the healant. Elongated MCs also contain higher amount of healant than spherical ones of same diameter. Self‐healing resins and composites can not only help prevent their premature failure but also improve their performance as well as service life and safety.more » « less
