An official website of the United States government
Efficient and sustainable biochemical production using low-cost waste assumes considerable industrial and ecological importance. Solid organic wastes (SOWs) are inexpensive, abundantly available resources and their bioconversion to volatile fatty acids, especially acetate, aids in relieving the requirements of pure sugars for microbial biochemical productions in industries. Acetate production from SOW that utilizes the organic carbon of these wastes is used as an efficient solid waste reduction strategy if the environmental factors are optimized. This study screens and optimizes influential factors (physical and chemical) for acetate production by a thermophilic acetogenic consortium using two SOWs—cafeteria wastes and corn stover. The screening experiment revealed significant effects of temperature, bromoethane sulfonate, and shaking on acetate production. Temperature, medium pH, and C:N ratio were further optimized using statistical optimization with response surface methodology. The maximum acetate concentration of 8061 mg L−1 (>200% improvement) was achieved at temperature, pH, and C:N ratio of 60 °C, 6, 25, respectively, and acetate accounted for more than 85% of metabolites. This study also demonstrated the feasibility of using acetate-rich fermentate (obtained from SOWs) as a substrate for the growth of industrially relevant yeast Yarrowia lipolytica, which can convert acetate into higher-value biochemicals.
more »
« less
This content will become publicly available on July 1, 2026
Solid-State Anaerobic Digestion of Organic Solid Poultry Waste for Biomethane Production
This study examines biodegradability (BD) and optimum conditions for the solid-state anaerobic digestion (SS-AD) of organic solid poultry waste (organs, intestines, offal, and unprocessed meat) to maximize biomethane production. Three main parameters, substrate-to-inoculum (S/I) ratio, pH, and temperature, were evaluated for the SS-AD of organic solid poultry waste. pH was evaluated at non-adjusted pH, initially adjusted pH, and controlled pH conditions at a constant S/I ratio of 0.5 and temperature of 35 ± 1 °C. The S/I ratios were examined at (0.3, 0.5, 1, and 2) at a controlled pH of ≈7.9 and temperature of 35 ± 1 °C. The temperature was assessed at mesophilic (35 ± 1 °C) and thermophilic (55 ± 1 °C) conditions with a constant S/I ratio of 0.5 and controlled pH of ≈7.9. The results demonstrate that the highest biomethane production and BD were achieved with a controlled pH of ≈7.9 (689 ± 10 mg/L, 97.5 ± 1.4%). The initially adjusted pH (688 ± 14 mg/L, 97.3 ± 1.9%) and an S/I ratio of 0.3 (685 ± 8 mg/L, 96.8 ± 1.2%) had approximately equivalent outcomes. The thermophilic conditions yielded 78% lower biomethane yield than mesophilic conditions. The challenge of lower biomethane yield under thermophilic conditions will be resolved in future studies by determining the rate-limiting step. These observations highlight that SS-AD is a promising technology for biomethane production from solid organic poultry waste.
more »
« less
- Award ID(s):
- 1914692
- PAR ID:
- 10613268
- Publisher / Repository:
- MDPI
- Date Published:
- Journal Name:
- Bioengineering
- Volume:
- 12
- Issue:
- 7
- ISSN:
- 2306-5354
- Page Range / eLocation ID:
- 712
- Format(s):
- Medium: X
- Sponsoring Org:
- National Science Foundation
More Like this
-
-
Small-scale anaerobic digestion (AD) can be an effective organic waste management system that also provides energy for small businesses and rural communities. This study measured fuel production from digestions of single and mixed feedstocks using an unheated, 2 m3 digester operated continuously in a temperate climate for over three years. Using local food waste, brewery waste, grease waste, and agricultural residues, this study determined that small-scale AD co-digestions were almost always higher yielding than single feedstocks during psychrophilic operation and seasonal temperature transitions. Agricultural residues from Miscanthus x giganteus had the greatest impact on biomethane production during co-digestion (4.7-fold greater average biogas %CH4), while mesophilic digestion of brewery waste alone produced the most biogas (0.76 gCH4 gVS−1 d−1). Biogas production during the transition from mesophilic to psychrophilic was temporarily maintained at levels similar to mesophilic digestions, particularly during co-digestions, but biogas quality declined during these temperature shifts. Full-time operation of small-scale, unheated AD systems could be feasible in temperate climates if feedstock is intentionally amended to stabilize carbon content.more » « less
-
null (Ed.)Abstract Anaerobic co-digestion is widely adopted to enhance process efficacy by balancing the C/N ratio of the feedstock while converting organic wastes to biomethane. Goat manure (GM) and cotton gin trash (CGT) were anaerobically co-digested in triplicate batch bioreactors. The process was optimized and evaluated utilizing mathematical equations. The liquid fraction of the digestate was analyzed for nitrate and phosphate. The co-digestions with 10 and 20% CGT having the C/N ratios of 17.7 and 19.8 yielded the highest and statistically similar 261.4 ± 4.8 and 262.6 ± 4.2 mL/g vs biomethane, respectively. The biodegradability (BD) of GM and CGT was 94.5 ± 2.7 and 37.6 ± 0.8%, respectively. The BD decreased proportionally with an increase in CGT percentage. The co-digestion having 10% CGT yielded 80–90% of biomethane in 26–39 d. The modified Gompertz model-predicted and experimental biomethane values were similar. The highest synergistic effect index of 15.6 ± 4.7% was observed in GM/CGT; 30:70 co-digestion. The concentration of nitrate and phosphate was lower in the liquid fraction of digestate than the feedstocks, indicating that these nutrients stay in the solid fraction. The results provide important insights in agro-waste management, further studies determining the effects of effluent application on plants need to be conducted.more » « less
-
Municipal solid waste (MSW) landfills are the third largest anthropogenic source of methane (CH4) emissions in the United States. Part of the CH4 generated in landfills is converted to carbon dioxide (CO2) by CH4-oxidizing bacteria (MOB) present in the landfill cover soil, whose activity is controlled by various environmental factors including temperature. As landfill temperature fluctuates substantially due to seasonal variations and series of reactions during waste decomposition, which may affect the microbial activity and thus, the rates of CH4 oxidation. This study aims at analyzing the effect of temperature on CH4 oxidation potential and microbial community structure of methanotrophs in laboratory-based microcosm studies on landfill cover soil. Landfill cover soil samples were incubated at selectively two temperatures 23C and 50C, and rates of CH4 oxidation were measured, and microbial community structure was analyzed using shotgun metagenome sequencing. CH4 oxidation occurred at both temperatures in soil microcosm tests with highest activity at 23C. A corresponding shift in the soil microbiota was observed, with a transition from mesophilic to thermophilic methanotrophs with increased incubation temperature. The study shows that temperature is a critical factor affecting rates of CH4 oxidation in landfill cover soil, and the changing rates of CH4 oxidation are in part driven by shift in the methylotroph community.more » « less
-
Among the sustainable initiatives for renewable energy technologies, anaerobic digestion (AD) is a potential contender to replace fossil fuels. The anaerobic co-digestions of goat manure (GM) with sorghum (SG), cotton gin trash (CGT), and food waste (FW) having different mixing ratios, volumes, temperatures, and additives were optimized in single and two-stage bioreactors. The biochemical methane potential assays (having different mixing ratios of double and triple substrates) were run in 250 mL serum bottles in triplicates. The best-yielding ratio was up-scaled to fabricated 2 L bioreactors. The biodegradability, biomethane recovery, and process efficacy are discussed. The co-digestion of GM with SG in a 70:30 ratio yielded the highest biomethane of 239.3 ± 15.6 mL/gvs, and it was further up-scaled to a two-stage temperature-phased process supplemented with an anaerobic medium and fly ash (FA) in fabricated 2 L bioreactors. This system yielded the highest biomethane of 266.0 mL/gvs, having an anaerobic biodegradability of 67.3% in 70:30 GM:SG co-digestion supplemented with an anaerobic medium. The BMP of the FA-amended treatment may be lower because of its high Ca concentration of 205.74 ± 3.6. The liquid fraction of the effluents can be applied as N and P fertigation. The Ca concentration was found to be 24.3, 25.1, and 6.3 g/kg in GM and GM:SG (TS) and SG solid fractions, respectively, whereas K was found to be 26.6, 10.8, and 7.4 g/kg. The carbon to nitrogen ratio of solid fraction varied between 2.0 and 24.8 for return to the soils to enhance its quality. This study involving feedstock acquisition, characterization, and their anaerobic digestion optimization provides comprehensive information and may assist small farmers operating on-farm anaerobic digesters.more » « less
